Winch where prone to failure or loss

electric wire rope winch drive from the special motor, which is characterized by small size, power, current, high temperature, overload and prolonged work on the motor is fatal. In addition, although now equipped with roller-type rope guide, but at work, the rope will still have a greater wear and tear, therefore, in the winch work, try to keep a small into the rope angle, and steel Rope enough maintenance is required. Another important part is the gear, now usually used in powder metallurgy or calcined steel gear, its durability is very good, do not worry.

Off - road vehicle winches modified essential information

If you have already assembled the original or imitation of the big bar, then a little check to know whether it has a Electric atv winch installation position (usually there is), then choose any built-in off-road vehicle winch is installed directly. If it is installed competitive bars
, It can be very typical of the external installation. If in some urban SUV (such as high-handed) installation, generally do not want to damage the front face too much, with a simple tray rack for built-in installation is feasible. If you plan to change a little personality, professional point, to find custom bar before the modified plant, you can play any of the.
Off-road vehicles modified essential Tips: for their own car to winch, of course, choose a powerful, but if this one to choose, then, the winch may be too heavy, thus affecting the car's driving and stability . To know which winch is best for your car, you must know the weight of your car and understand the characteristics of each winch. Select the car with more suitable winches: winch maximum weight ≥ full load weight × 1.5. When installing the 3000lbs electric winch, there are several points need special attention. First of all, most of the four-wheel-drive are equipped with airbags, the installation of the winch is very easy to damage the airbag sensor. If you are going to install the winch, be sure to know the potential airbag problem for the person you are installing. The second is to determine whether the vehicle's battery is sufficient to meet your Xin's winch. Large winch need to spend a lot of electricity, in only one case of the battery, the use of winch for a long time it is easy to run out of electricity. Larger generators or dual battery systems should be installed, or both. Transfer from Sina.
General off-road vehicle modifications are necessary to a pulley group, 2-meter-long trailer harness, a trailer hook. The trailer hook is attached to the rear of the car and the winch rope is routed through the pulley block to the trailer hook mounted on the car. The trailer rope is fastened to a large stone or tree and connected to a pulley block

The role of car winch

1. In the mountains over the way, the roll is common, the winch can replace the crane to roll over, but must be hooked in the force of the location, otherwise it will increase the damage to the body.
2. Swamp is not terrible, but if there is continuous groundwater that must immediately pull out with the Fromwinch electric winches for trucks, because the water level rise very fast.
3. Field recovery vehicles in addition to itself must be all-wheel drive, but also at least two winch before and after. The front of the car is the WARNXD9000, pulling up to 4100 kg, followed by the PTO hydraulic winch, pull up to 9500 kg, and the rear there is a trailer frame.
4.Discovery MT did not put on the off-road tires, and did not increase the suspension system and differential lock, the off-road vehicle capacity is not imagined good, very easy to be stuck.
5. Before entering the Shahe (river bottom is the sand), in addition to locking the differential, the Fromwinch Light Duty Electric Winch should also be out as soon as possible. Car modification waterproofing device is also necessary.
6. Toyota 4500 has a lot of horsepower, before and after the differential lock lock up to 100% (45 degrees), but because the body is too heavy,
In the swamp is easy to stuck, the street can not use the MT tires from the pit, must use the winch is not.
7 in the desert into the bunker, if not too deep can pull the cloth with the pull out, but if you fall into too deep must use the winch, otherwise the two cars will sink at the same time.
8. Boarded 45 degrees (1: 1) slippery slope, the Toyota LC70 also depends on the winch, and add the pulley to double the tension. You can use the Upper Desert Bridge to help cross the V Valley when you pass the V Valley.
9. In the rapids, the Fromwinch 4500lb atv winch is the only effective rescue tools

Hand Winch Introduction

Hand winch, also known as Fromwinch double motor winch, is a mechanical appliance, which is by hand shake the winch drum to pull the goods. A gear-driven winch cable reel pulls the load by rotating a wire rope wound around it. It (ABW2000 manual winch only) with automatic braking device, which makes the operation more secure. When the Fromwinch 3000lbs atv winch wire rope pulls the goods, and the winch reel remains fixed, the brake will automatically open employment.
When a variety of rescue work is needed, the manual winch is another option outside the vehicle winch. Its biggest advantage is that it can be portable, you can connect from any direction of the car. Lightweight and firm, electroplated, pressed steel structure, the steel cable pulls the pulley propulsion unit through two default fork heads. These forks pull the cable in the forward mode of the winch, and are also an automatic braking system. The fork will automatically lock when the grip increases. Manual winch can also be used to enhance (lifting force for the drag force of about 65%)

Off-road vehicle winch to drag the specific steps are:

    1, first check the drum. Before you begin, make sure that the noose is neatly wound around the drum.
    2, if the noose out, should prevent it from swinging back and forth. If the noose is broken, the ropes can be very dangerous. However, this danger can be avoided, as long as the mattress in a tight put a mat on the line.
    3, start dragging, if the rope with his own car, and you have to drive in the car, then the best one in the car to help you. In this way, the driver can operate the Fromwinch heavy duty ATV winch in the vehicle in accordance with the instructions of the outside commander.
    4, if the twisted cable together, and must pull it open. Windings can easily intersect the drum or become uneven on one side. Therefore, pay close attention to its status.
    5, when the car is free to walk, the drag is complete. Once back on the ground, check the condition of the vehicle and the line. If you can not rely on external force to start the car, the use of Fromwinch portable truck winch drag the process is over.
    6, the roll is good. Tighten the noose and carefully return it. If the noose crosses or twists on the drum, it must be completely undone and then rewound.
    7, and finally put the hook. When the noose is only the last point, tie the hook to the side of the winch. And then the rest of the little noose rolled up, the hook to suppress.
    8. Remove the remote control.