Automobile electric winch fixed fulcrum

If you want to pull the car forward, there must be a safe place fixed pivot, the fulcrum must also be able to bear the full weight of the car. The most basic principle is to move in front of the car pulled, do not appear angle. Off-road driving, the most commonly used fulcrum is the tree. However, if the Fromwinch best 4x4 winches to rescue another car was trapped, rescue vehicles can also be used as fulcrum, but in this case, we must block the wheel, so that it can not scroll, that is to ensure that rescue vehicles will not move.
No matter what kind of winch, if there is no safety fulcrum, you can not give full play to its potential. In other words, the fixed fulcrum is the use of winch is a crucial step.
In the use of Fromwinch electric wireline winch, also need a strap to connect the winch, fulcrum and wicker hook and U-shaped lug. If the winch does not have enough power to drag the weight with a single line, you need to use two-wire to enhance its strength, then also need a tight line pulley.
Another point to note that with the tree as the fulcrum, to use the widest part of the tape, so as not to Le belt to the tree to destroy the trees, and be sure to tape the left and right ends were tied to the hanging ears on both sides of the The length of the tape should be the same.

Electric winch installation

The use of the Fromwinch 4000lbs electric winch must of course start with the installation. This step is not complicated, but it is the most important step, because it is directly related to the subsequent steps and the use of winch effect. The most important thing here is to pay attention to the status of the noose drum, before the start and the entire process must ensure that the use of a uniform winding twist. Specific installation process is as follows:
    1. Insert the remote control. Insert the remote control connector end into the winch.
    2, do not let the remote control hanging drape. If you are a driver, operating the remote control in the driver's seat, then the excess connection around the side mirrors in the car side, the work will be much more convenient.
    3, pull the noose, with the remote control cable will release a little point and then open the Fromwinch two motor winch installed on the side of the noose hook.
    4, open the clutch. Be sure to turn on the hook and then turn the clutch on again.
    5, hand-held noose hook. When the noose is pulled down from the drum, hold the hook with one hand, so that no matter how long it is pulled, it will not be able to reach the hook.
    6, will be pulled to the fulcrum fulcrum, lock the clutch.
    At this point the winch is ready.

Off - road vehicle electric winch

Fromwinch electric wire winch is obtained from the car itself to drive the motor drive noose. This type of winch is convenient because it can be operated anywhere from the knobs on the remote control. It is the biggest advantage is that as long as the battery power can be used.
However, the power of the Fromwinch electrical cable winch motor is generally only a few horsepower, so how can a small power motor to drag a heavy car or other heavy objects it? Secret in the use of reducer. Even if the motor can only send a small force, but the reducer can be transformed into a powerful force. Different winch manufacturers use this principle is to create a different product.
Most winchs on the market use planetary gears as reducers. Planetary gear has the advantage of smaller size and the resulting relatively large reduction ratio, and the gears of the contact points more long service life. Fromwinch 4000lb atv winch is usually installed in a small space, so the smaller the lighter the better. Planetary gears can achieve this requirement, but also produce a larger reduction ratio, so again ideal.
Simply put, the working mechanism inside the winch is: the electric power from the car to drive the motor first, and then drive the drum motor rotation, drum and drive the drive shaft, the drive shaft and then drive the planet gear, and then have a strong torque. Subsequently, the torque is transmitted back to the drum, the drum will drive the winch. There is a clutch between the motor and the gear unit that can be switched by a handle. Braking unit in the drum, when the noose tension, the drum is automatically locked.

How to Operate Electric Winch Properly

First, the Fromwinch competition auto Winch must be easy to see on the place, not on the inconspicuous corner, and must be safe and open place. The traction macro diverter pulley should be installed at a distance not less than 40 times the length of the drum. Height must exceed the wooden stack 2-3 meters, is strictly prohibited in the crib on the guide pulley. Operation of the time need to focus on the operation when the rigorous operation of more than one person, run time, is strictly prohibited all personnel into the rope angle zone. In the inspection and maintenance, we found that one of the following circumstances wire rope must be re-replaced or scrapped: foreign wire wear to wire diameter of one-half; in a pitch within the number of broken wire 6-8 apply; The use of wire rope, the pitch elongation of 10% of a wire all broken, there are dead ends or serious corrosion of wire rope.
Second, before starting the Fromwinch electrical cable winch machine, you should check whether there is a sufficient number of oil in the transmission, the need for lubrication of the parts have been lubricated, the gear teeth and teeth between the debris. In winter, the lubricating oil in the gear reducer tends to condense, so check the shaft of the inspector before starting. When starting the electric winch, brake the reel, open the electrical switch, connect the necessary gears in the gear unit, and then link the motor Of the clutch, that is, to rotate the reducer shaft.

We are the well known manufacturers and suppliers of electric wire winch.

We are the well known manufacturers and suppliers of electric wire winch. Fabricated from best quality raw material our range is appreciated for dimensional accuracy, robust construction and operational efficiency. The electric wire winch offered by us are used in repair jobs and to carry out erections. The winches can also be custom made in accordance with the load lifting capacity.
Fromwinch electric winch manufacturers

, from where you can buy the right kind of winches for your perusal. Whenever you are buying winches, make sure that check the line being used in the winches. There are few hydraulic winch manufacturers , who tends to use the steel cable which works amazingly even if expose to great amount of heat. These lines are also made from synthetic rope which melts quite easily when exposed to heat therefore it is better to avoid such winches. However, it is true that the synthetic ropes are less prone to dangers if it is broken due to accidents. With the availability of many electric winch manufacturers, it has become quite easy to get winches that have both the features.

Electric atv winch features

Electric atv utv winch features:
1)All metal, high precision, high strength of the 3 planetary gear groups
2)Waterproof motor
3)Long-life sealed control switch
4)Full sealed large current contactor
5)Install four power wire convenient
6)Hot-dip galvanized steel for air level
7)Included components: mounting plate, roller fairlead, G70 hook, contactor, handle switch, portable truck winch

sets, hardware, hand saver strap,
8)Sheath of rubber, ribbon, instruction, EPS packaging, colored box and more
9)Small volume, light weight, strong tension and more
10)Suitable for small SUV, beach all-terrain vehicle and light vehicle outdoor operation.

Be prepared for anything with our selection of atv utv winch, recovery kits and accessories

Be prepared for anything with our selection of atv utv winch

, recovery kits and accessories. For those that own an ATV or UTV, you know it’s always necessary to carry equipment in the event you need to tow, haul or recover from a fall off the trail. This is one area where you don’t want to buy cheap or poorly made equipment. We carry synthetic ATV winch ropes, ATV/UTV winches, recovery gear, trail gear,  winch line saver, winch isolaters, ATV winch hooks, UTV accessories and Winch Cable Dampener. We’ve made it so you can purchase items individually or in a kit for ease.
For ATV’ers going out on a trail ride, make sure you’re prepared with ATV accessories like a first aid kit, a recovery shovel, a 5-in-1 tool (axe, shovel, pick, saw and compass), a hatchet, a commando axe and a flashlight.